[sstarch1]

Got a call from my dealer saying that my part has arrived for my recall...to which i said ...WHAT?

He said that it was nothing major, to which i pressed harder to find out that it was a, and i dont remember the exact name, air conditoning line rail, or something like that.

Just an FYI, wanted to pass on my knowledge.

[Alan(iX)]

Originally Posted by sstarch1

Got a call from my dealer saying that my part has arrived for my recall...to which i said ...WHAT?

He said that it was nothing major, to which i pressed harder to find out that it was a, and i dont remember the exact name, air conditoning line rail, or something like that.

Just an FYI, wanted to pass on my knowledge.

Since your car is an early car, this might be what it is for.
If your car in one of these chassis number ranges ?
E92 335i, PV80025 – PV80659
E92 335iA, PV82032 – PV82955


SI B64 11 06
Heating and Air Conditioning September 2006
Technical Service

PERFORM THE PROCEDURE OUTLINED IN THIS SERVICE INFORMATION ON ALL AFFECTED VEHICLES THE NEXT TIME THEY ARE IN THE SHOP FOR MAINTENANCE OR REPAIRS, AND PRIOR TO RETAIL DELIVERY.

SUBJECT
Service Action: Install Bracket for Air Conditioning System Pressure Line

MODEL
E92 (3 Series)

SITUATION
The pressure line for the air conditioning compressor to condenser may develop a leak, resulting in a loss of refrigerant, poor air conditioning performance, and possible compressor damage.

CAUSE
The pressure line for the air conditioning compressor to the condenser may leak as a result of vibrations over the course of time.

AFFECTED VEHICLES
This Service Action involves E92 (3 Series) vehicles which were produced from May 15, 2006 to August 10, 2006.

In order to determine if a specific vehicle is affected by this Service Action, it will be necessary to utilize the "Service Menu" of the DCS (Dealer Communication System). Based on the response of the system, either proceed with the corrective action or take no further action.

The Chassis Number Ranges listed below are only for informational purposes and are not to be considered as the only deciding factor.

Model
Chassis Number Range

E92 335i
PV80025 – PV80659

E92 335iA
PV82032 – PV82955

PROCEDURE
Install an additional support bracket for the pressure line at the air conditioning compressor as follows:

Remove the left-side charge air duct. Refer to Repair Manual instructions RA 64 52 521 or RA 11 61 368.

Install the bracket (1) to the pressure line and secure to the air conditioning compressor using the M5x12 screws (2). Tightening torque: approximately 7.6 Nm.

Reinstall any previously removed components.

PARTS INFORMATION
Part Number............. Description..................Quantity

64 53 9 132 483.....Pressure Line Bracket.......... 1

07 11 9 902 815.....M5x2 Fillister-head screw..... 2

LABEL INSTRUCTIONS

This Service Action has been assigned code number 476 After the vehicle has been checked, and corrected if necessary, obtain a label (SD 92-295) and:

emboss your BMW dealer warranty number in the middle of the label (1);
punch out code number 476 printed on the label and,
affix the label to the B pillar as shown.

If the vehicle already has a label from a previous Service Action/Recall Campaign, affix the new label next to the old one. Do not affix one label on top of another one because a number from an underlying label could appear in the punched-out hole of the new label.

WARRANTY INFORMATION
Reimbursement for this Service Action will be via normal claim entry utilizing the following information:

[Straz M3]

Yes I am 80887...

[sstarch1]

I was in the production range (produced Aug 1st i think), so this is applicable to me.

[MrSilver]

I haven't gotten a notice to bring my car in.

[Xon]

Some times where I work (at a wv and audi garage) We repair this things when the cars come inn for service. Offen whitout the owners knowing

[thealbert]

Is this only applicable to coupes and not sedans? So i'm guessing its not 335i specific but coupe specific?

[DFW_M]

Originally Posted by MrSilver

I haven't gotten a notice to bring my car in.

you're a lawyer, they send notices to those last...